DIGITAL INSPECTION

GENERAL NOTES

OIL CHANGE STICKER

TECHNICIAN NOTE

Oil change is not due at this time.

GAUGES

WARNING LIGHTS AND MESSAGES

TECHNICIAN NOTE

Multiple lights on, see notes under driveability below for check engine light. Further diagnostic time required to check other malfunction indicators.

INTERIOR LIGHTS: DASH/HEATER/RADIO/DOME/OTHER

POWER LOCKS AND WINDOWS

TECHNICIAN NOTE

Drivers power window makes noise when operating.
Drivers rear wing window is not attached to latch.

RECOMMENDATION

Pull door panel to inspect drivers power window for cause of noise.
Reattach drivers rear wing window to latch, a glass shop could probably handle this.

HEATING AND AIR CONDITIONING

CABIN AIR FILTER

TECHNICIAN NOTE

Vehicle is equipped with a cabin air filter and most manufacturers recommend replacing the filter every year or 20k miles.

RECOMMENDATION

Disassembly required to inspect this filter. Did not check. If it hasn't been changed in the listed interval it would be a good idea to do so.

HORN OPERATION

PARKING BRAKE

REAR VIEW MIRRORS

WINDSHIELD WIPERS(FRONT AND REAR)

TECHNICIAN NOTE

Poor Performance

RECOMMENDATION

Recommend replacing wiper blades, including the head lamp wipers.

WINDSHIELD WASHER(FRONT AND REAR)

INTERIOR DOOR HANDLES

EXTERIOR DOOR HANDLES

HEADLIGHTS(LOW/HIGH BEAM)

TURN SIGNALS

FOG LIGHTS

TECHNICIAN NOTE

Rear fog light is out.

RECOMMENDATION

Replace passenger fog lamp bulb and check operation.

PARK LIGHTS

TECHNICIAN NOTE

Driver's rear outer park light is out.

RECOMMENDATION

Replace rear park lamp bulb and check operation.

MARKER LIGHTS

BRAKE LIGHTS

HAZARD LIGHTS

BACK UP LIGHTS

LICENSE PLATE LIGHT

TECHNICIAN NOTE

The license plate light is out.

RECOMMENDATION

Recommend replacing license plate bulb(s). If the bulb is not the issue further diagnosis may be required.

BATTERY

TECHNICIAN NOTE

The battery is testing good.

CCA:550 of 650

WINDSHIELD WASHER FLUID

AIR FILTER

TECHNICIAN NOTE

Good for now, I'd replace it at next oil change.

INDUCTION SYSTEM

ENGINE OIL

TECHNICIAN NOTE

There are a few leaks on this vehicle. The major leak is from the engine oil cooler lines, start there.

RECOMMENDATION

Replace engine oil cooler lines.

ENGINE COOLANT

TECHNICIAN NOTE

We recommend exchanging most newer coolant types every 5 years or 100k miles. Standard coolant we recommend every 2 years or 24k miles.

TRANSMISSION FLUID

TECHNICIAN NOTE

We recommend exchanging most vehicle's transmission fluid every 50k miles.

POWER STEERING FLUID

TECHNICIAN NOTE

We recommend changing power steering fluid approximately every 75k miles.

BRAKE FLUID

TECHNICIAN NOTE

We recommend replacing brake fluid every 2 years or 30k miles.

CLUTCH FLUID

TECHNICIAN NOTE

Does not apply to this vehicle.

DRIVEABILITY

TECHNICIAN NOTE

P0410 and P0172 stored.
P0410: Air pump is inoperative.
P0172: Visual inspection of induction system shows multiple disconnected vacuum hoses, intercooler piping is loose.

RECOMMENDATION

Replace AIR pump and recheck secondary air system operation.

For the rich condition, first thing we need to do is replace all suspect vacuum lines, then smoke test entire induction and intake system. After everything is squared away there we can see how the fuel trims are.

FUEL FILTERS

TECHNICIAN NOTE

We recommend replacing fuel filters on gas vehicles every 15k miles on gas vehicles.

On diesel vehicles we recommend replacing the fuel filter(s) as indicated by info display, or if not equipped with an info display every other oil change.

RECOMMENDATION

Recommend replacing fuel filter.

DRIVE BELTS

COOLING SYSTEM HOSES

ENGINE COOLING SYSTEM AIRFLOW

TIMING BELT

TECHNICIAN NOTE

This vehicle is equipped with a timing belt. Timing belts should be replaced as indicated on your vehicle's maintenance schedule, usually 60-90k miles.

RECOMMENDATION

Timing belt was changed at 143k miles according to sticker under hood. I like to change timing belts closer to the 60k than 90k interval, time to start thinking about it at least.

TIRE CONDITION

TIRES ROTATED?

TECHNICIAN NOTE

No

TIRE PRESSURE

LUG NUTS/WHEEL STUDS

WHEEL BEARINGS

FRONT BRAKES

REAR BRAKES

BRAKE CALIPERS AND WHEEL CYLINDERS

BRAKE HOSES

TECHNICIAN NOTE

Brake hoses are cracking.

RECOMMENDATION

Recommend replacing all brake hoses on this vehicle. Best to do them all at the same time.

BRAKE BOOSTER AND MASTER CYLINDER

CV JOINTS/HALF SHAFTS

TECHNICIAN NOTE

Passenger side CV axle is ripped, drivers side is close to ripping.

RECOMMENDATION

Replace cv axles.

SUSPENSION/DRIVETRAIN BUSHINGS/JOINTS

TECHNICIAN NOTE

The vehicle's suspension bushings are worn but not to a critical degree.

BALL JOINTS

SHOCKS/STRUTS

TECHNICIAN NOTE

Right front strut mount is bad. There is a severe clunk from that corner everytime you go over a bump. It may or may not be caused by the mount but that would be a great place to start.

RECOMMENDATION

Recommend replacing shocks/struts and mounts on this vehicle.

SWAY BAR LINKS/BUSHINGS

TIE ROD ENDS

IDLER/PITMAN ARMS

TECHNICIAN NOTE

Does not apply to this vehicle.

STEERING DAMPER

TECHNICIAN NOTE

Does not apply to this vehicle.

STEERING LINKAGE

AXLE FLUID FRONT

TECHNICIAN NOTE

Does not apply to this vehicle.

AXLE FLUID REAR

TECHNICIAN NOTE

Does not apply to this vehicle.

TRANSFER CASE/POWER TRANSFER UNIT FLUID

TECHNICIAN NOTE

Does not apply to this vehicle.

DRIVE SHAFT FRONT

TECHNICIAN NOTE

Does not apply to this vehicle.

DRIVE SHAFT REAR

TECHNICIAN NOTE

Does not apply to this vehicle.

MOTOR MOUNTS

EXHAUST SYSTEM

ENGINE AND DUST COVERS