WEDNESDAY, SEPTEMBER 19, 2018
PETER REIDELBACH
2001 VOLKSWAGEN EUROVAN GLS
Vehicle Inspection Score
12
POINTS URGENT
1
POINTS NON-URGENT
72
POINTS PASSED
EUROPEAN VEHICLE DIAGNOSTICS/ P0411 CEL ON POSSIBLE REPLACEMENT OF MASS AIR FLOW SYSTEM. CONFIRM IF NEEDED REPLACEMENT OF OXYGEN SENSORS.
TECHNICIAN NOTE
Check engine light on prior service. Various faults stored p1152 long-term fuel trim additive are Bank 1 range to system too lean intermittent, p0101 mass air flow sensor implausible signal intermittent, P0411 secondary air injection system incorrect flow detected, P0420 catalyst system Bank 1 efficiency below threshold intermittent, and p1198 oxygen sensor heater circuit bank 1 sensor 2 electrical malfunction intermittent. Verified secondary air pump is shorted out internally, also verified bank 1 sensor 2 oxygen sensor has failed internally. Bad mass air flow sensor connector retaining clip broken and missing, on test drive map sensor readings were sporadic, removed mass airflow sensor and found it to be very dirty and full of debris. Cleaned mass air flow sensor of all debris and oil. After cleaning MAF sensor run ability worsened but stabilized along with readings.
RECOMMENDATION
Recommend replacing bank 1 sensor 2 oxygen sensor, secondary air pump and secondary air pump relay, and cleaning intake boot and throttle body and replacing mass air flow sensor
FOUR SENSE DIAGNOSTICS - BEARING NOISE FRONT
TECHNICIAN NOTE
Found loud bearing noise from front end to be coming from serpentine belt tensioner pulley
RECOMMENDATION
Replace serpentine belt tensioner assembly and serpentine belt
MALFUNCTION INDICATOR (CEL)
TECHNICIAN NOTE
Check engine light on prior to service
RECOMMENDATION
See diagnostic report above.
INSPECT: SUNROOF OPERATION/ CONVERTABLE TOP
TECHNICIAN NOTE
Sunroof motor cover missing prior service, when operated motor has excessive play. Did not attempt to fully open sunroof
RECOMMENDATION
Would like more information if this is one of customers concerns.
FREQUENCY
Check every 36 months or 30000 mi
INSPECT: FRONT SUSPENSION
TECHNICIAN NOTE
During test drive notice thumping from what sounds like strut mounts
RECOMMENDATION
Front struts seem to have been replaced may have been installed incorrectly
FREQUENCY
Check every 3 months
DRIVETRAIN- TECHNICIAN NOTE 8A
TECHNICIAN NOTE
Transmission fluid all over transmission and front differential transmission pan leaking Category 3
RECOMMENDATION
Recommend full transmission service and cleaning up transmission
FREQUENCY
Check every 30000 mi
INSPECT: AIR FILTER CONDITION
TECHNICIAN NOTE
Air filter dirty Category 3
RECOMMENDATION
Replace air filter
FREQUENCY
Check every 12 months or 12000 mi
LUBE, OIL & FILTER - FULL SYNTHETIC - EUROPEAN SPECIFICATIONS
VEHICLE MAINTENANCE INSPECTION
***BULB REPLACEMENT***CUSTOMER HAS PREAUTHORIZED BULB REPLACEMENT UP TO $25.00 IN COST (PLUS TAX). CUSTOMER WILL BE CALLED FOR AUTHORIZATION OF BULB REPLACEMENT BEYOND $25.00 IN COST. IN.________
RESET: SERVICE INTERVAL INDICATOR/DISPLAY
FRONT END OF VEHICLE
PASSENGER SIDE OF VEHICLE
REAR END OF VEHICLE
DRIVER SIDE OF VEHICLE
SERVICE REMINDER (SRI)
FREQUENCY
Check every 6 months
STABILITY CONTROL MALFUNCTION (ESP)
AIR BAG MALFUNTION (SRS)
TPMS WARNING
INSPECT: HORN OPERATION
INSPECT: INTERIOR LIGHTING
FREQUENCY
Check every 6 months or 6000 mi
INSPECT: LICENSE PLATE LAMP(S)
INSPECT: MARKER/HAZARDS/TURN LAMPS
BODY ELECTRICAL: ADDITIONAL NOTES
FREQUENCY
Check every 6 months or 6000 mi
INSPECT: WINDOWS OPERATION
INSPECT: POWER MIRROR OPERATION
INSPECT: DOOR LOCKS/ CHILD SAFETY LOCKS
INSPECT: DOOR, TRUNK, HOOD OPERATION
INSPECT: GAS FILLER DOOR OPERATION
BODY MECHNICAL: ADDITIONAL NOTES
FREQUENCY
Check every 6 months or 6000 mi
INSPECT: BLOWER MOTOR/ DEFROST OPERATION
INSPECT: HEATER PERFORMANCE
CLIMATE CONTROL: ADDITIONAL NOTES
INSPECT MASTER CYLINDER
PICTURE: TIRE SIZE/BRAND/SPECS.
INSPECT: FRONT LEFT TIRE CONDITION AND PRESSURE
TECHNICIAN NOTE
Upon inspection of your front driver side rear tire we found the measurement to be 7-8 mm.
FREQUENCY
Check every 6 months or 6000 mi
INSPECT: FRONT RIGHT TIRE CONDITION AND PRESSURE
TECHNICIAN NOTE
Upon inspection of your passenger front tire we found the measurement to be 7-8 mm
FREQUENCY
Check every 6 months or 6000 mi
INSPECT: REAR LEFT TIRE CONDITION AND PRESSURE
TECHNICIAN NOTE
Upon inspection of your driver side rear tire we found the measurement to be 6-7 mm.
FREQUENCY
Check every 6 months or 6000 mi
INSPECT: REAR RIGHT TIRE CONDITION AND PRESSURE
TECHNICIAN NOTE
Upon inspection of your passenger rear tire we found the measurement to be 6-7 mm.
FREQUENCY
Check every 6 months or 6000 mi
WHEELS & TIRES: ADDITIONAL NOTES
INSPECT: STEERING GEAR/ STEERING LINKAGE
INSPECT: REAR SUSPENSION
FREQUENCY
Check every 3 months
STEERING/SUPENSION: ADDITIONAL NOTES
INSPECT: AXLE SHAFTS AND BOOTS
INSPECT: DRIVESHAFT (U-JOINTS)
INSPECT: CONSTANT VELOCITY BOOTS & BANDS
INSPECT: CATALYTIC CONVERTER
FREQUENCY
Check every 12 months or 12000 mi
INSPECT: EXHUAST HANGERS/CLAMPS
INSPECT: RESEVIOR / EXPANSION TANK
FREQUENCY
Check every 12 months
INSPECT: ENGINE GASKETS
INSPECT: OIL LEVEL AND CONDITION
TECHNICIAN NOTE
Oil is the proper level but dark
RECOMMENDATION
Replacing as per customer's request
FREQUENCY
Check every 3 months
ENGINE - TECHNICIAN NOTE 11A
INSPECT: IGNITION COILS/ CONNECTORS
FREQUENCY
Check every 6 months
ENGINE ELECTRICAL: TECHNICIAN NOTE 12A
TECHNICIAN
E, ANTONIO
UNION MOTORWORKS
7520 AURORA N
SEATTLE, WA 98103
(206) 728-2212
COPYRIGHT © 2024